2015 Volkswagen Golf Variant Repair Manual - Body Interior

Online Pdf 2015 Volkswagen Golf Variant Repair Manual - Body Interior

Use pneumatic and electric tools only to loosen threaded parts and fasteners. Never use these tools to tighten fasteners, especially on light alloy parts. Always use a torque wrench to tighten fasteners to the tightening torque listed.

Keep sparks, lighted matches, and open flame away from the top of the battery. If escaping hydrogen gas is ignited, it will ignite gas trapped in the cells and cause the battery to explode.

Be mindful of the environment and ecology. Before you drain the crankcase, find out the proper way to dispose of the oil. Do not pour oil onto the ground, down a drain, or into a stream, pond, or lake. Consult local ordinances that govern the disposal of wastes.

The air-conditioning (A/C) system is filled with a chemical refrigerant that is hazardous. The A/C system should be serviced only by trained automotive service technicians using approved refrigerant recovery/recycling equipment, trained in related safety precautions, and familiar with regulations governing the discharging and disposal of automotive chemical refrigerants.

Before doing any electrical welding on vehicles equipped with anti-lock brakes (ABS), disconnect the battery negative terminal (ground strap) and the ABS control module connector. Do not expose any part of the A/C system to high temperatures such as open flame. Excessive heat will increase system pressure and may cause the system to burst.

When boost-charging the battery, first remove the fuses for the Engine Control Module (ECM), the Transmission Control Module (TCM), the ABS control module, and the trip computer. In cases where one or more of these components is not separately fused, disconnect the control module connector(s).

Some of the vehicles covered by this manual are equipped with a supplemental restraint system (SRS), that automatically deploys an airbag in the event of a frontal impact. The airbag is operated by an explosive device. Handled improperly or without adequate safeguards, it can be accidentally activated and cause serious personal injury. To guard against personal injury or airbag system failure, only trained Volkswagen Service technicians should test, disassemble or service the airbag system.

Do not quick-charge the battery (for boost starting) for longer than one minute, and do not exceed 16.5 volts at the
battery with the boosting cables attached. Wait at least one minute before boosting the battery a second time.

Never use a test light to conduct electrical tests of the airbag system. The system must only be tested by trained
Volkswagen Service technicians using the VAG 1551 Scan Tool (ST) or an approved equivalent. The airbag unit
must never be electrically tested while it is not installed in the vehicle.

Some aerosol tire inflators are highly flammable. Be extremely cautious when repairing a tire that may have been
inflated using an aerosol tire inflator. Keep sparks, open flame or other sources of ignition away from the tire repair
area. Inflate and deflate the tire at least four times before breaking the bead from the rim. Completely remove the
tire from the rim before attempting any repair.

When driving or riding in an airbag-equipped vehicle, never hold test equipment in your hands or lap while the
vehicle is in motion. Objects between you and the airbag can increase the risk of injury in an accident.

2015 Volkswagen Golf Variant Repair Manual - Body Interior For Free

(0) Comments

Leave A Response

Your email address will not be published with your comments.

Reload Image